Home   | About Us   | Gift Registry   | My Account   | Contact Us   | Blog   |
0 item(s) / Total: $0
cornpelletstoves.com

    AUTHORIZED DEALER with Quality and Service
 
Home > Corn Multifuel Furnace and Boiler

FORCED-AIR THREE CORN WOOD PELLET MULTIFUEL FURNACE STOVE, 120,000 BTU/Hr

FORCED-AIR THREE CORN WOOD PELLET MULTIFUEL FURNACE STOVE, 120,000 BTU/Hr
FORCED-AIR THREE CORN WOOD PELLET MULTIFUEL FURNACE STOVE, 120,000 BTU/Hr
Email a friend Email a friend
Price
Your Price:  
$6,150.00
Availability:
In Stock.
Quantity
Add to Gift Registry
Description
THE FORCED-AIR DUCTOR MODEL III (THREE)
120,000 BTU/Hr, Heats up to 4500 Sq Ft
Much
HIGHER QUALITYColor=red>
than MODEL II, pay more get more
MULTI-FUEL FURNACE that will CONNECT to DUCTWORK
CORN & WOOD PELLET MULTIFUEL FURNACE (STOVE)
AVAILBLE in THREE MODELS: I, II, and III

WORRIED ABOUT CORN PRICES RISING...DON'T JUST BUY A MULTI-FUELED UNIT AND BURN ANOTHER FUEL


ADD-ON FURNACE will reduce your dependance on more Expensive Fuel

Introducing the NEW MULTI-FUEL Model III (THREE), the Forced-Air Ductor, a multi-fueled furnace (stove) that will hookup to your existing forced air ductwork either as a Primary (Stand Alone) or a Secondary (Add-On). It is availble in three (3) Models. Model III is 120,000 BTU/Hr and is the one being sold and is much HIGHER QUALITY than Model II and is worth $2605 more than Model II. Model III has much higher quality construction with a variable speed 1650 CFM Room-Air Blower 1/2 Amp. Model I is 80,000 BTU/Hr. ($2715 less), and Model II is 105,000 BTU/Hr. ($2605 less). By request only there is a 4th Model IV (Four) at 165,000 BTU/Hr for $2400 more. This multi-fueled Furnace will produce up to 120,000 BTU/Hr (Model III) and will burn corn, wood pellets, soybeans, sunflower seeds, wheat, cherry pits, olive pits, engineered pellets, and any biomass fuel. We suggest you experiment around. If corn prices skyrocket, then dump the corn for a lower cost fuel. This Multi-fueled Furnace will fit any size of home, garage, farm house, business at 2,000 sq. ft. to 4,500 sq. ft. Connect it with your DUCTWORK and run the room air STRAIGHT UP into your existing ductwork. All you need are a Duct Plenum Take-Off 22" W x 22" D and a matching Back-Draft damper. A Cold Return Air filter bracket 15"H x 20"L is built into the cold-air return air module (16-1/8"W x 21-5/16"D rectangular) at rear side bottom. The Cold-air will mount to either side. Also a POWER OUTAGE Module is available for this unit for $179. A Digital Thermostat option ia available for $68 and a Remote Control option is available for $225. This unit Model III retails at the manufacturer recommended selling price MRSP of $6,599.00 (Model III). After selling Model III at a discount at $6100, it is $2605 more than Model II $3,495, but is does more with bigger Blower Motor 1650 CFM 1/2 Amp among other things ... spend more .... and you get more ... ! Gigantic installations by special request requiring 165,000 BTU/Hr should buy our Model IV (Four) at $2400 more add-on.

Ebay Rules allow the highest bidder to Buy-It-Now immediatelyCOLOR=red> with an early auction ending. There has to be more than 12 hours left in the listing. To do that call us at 1-319-298-0500COLOR=red> or contact us at Ebay's Ask-a-questionCOLOR=blue> located at the bottom of this listing in the far lower left-hand side or use Ebay's Contact Seller. This is consistent with Ebay rules and we have no intent to bypass them or bypass Ebay in a sale.

It is still wise to buy one now and get it delivered before the cold fall months arrive. Get your corn furnace (stove) purchased now. Also visit our Ebay Store for other related items: . Always buy from Dealers, not from individuals.

MODEL III (THREE) better than MODEL II (TWO)

Model III is better than Model II (Two) and here are the reasons why:

  • Bigger Room-Air blower 1650 CFM, three speed, 1/2 AMP
  • 15,000 BTU/Hr more heat
  • Auto Ignition
  • Hot-Air Plenum bigger 22x22 inches, more air delivery
  • Cold-Air Return Plenum bigger 16x20 inches, more air delivery
  • Fire Pot Bigger better more heat
  • Fire Pot Heavier Stainless Steel contruction, lasts longer
  • Hot-water Coil Capability, available as Option
  • Electric Grid Heat Backup, available as Option
  • Heavier Gage Steel, better built
  • Warranty Limited Lifetime, longer more coverage
  • Spend more and get more for your money.

PICTURE Descriptions ... left to right. Both Models I and II look similar.

  1. Top Row ... left to right
  2. FORCED-AIR MULTIFUEL FURNACE, MODEL III (THREE) in a closeup view
  3. FORCED-AIR MULTIFUEL FURNACE, MODEL III (THREE) in a long distance view
  4. FORCED-AIR MULTIFUEL FURNACE, MODEL III (THREE) in an installation
  5. FORCED-AIR MULTIFUEL FURNACE, MODEL III (THREE) in a pictorial sketch
  6. Hopper and Auger at bottom of bin
  7. Ash Drawer

  8. Second row ... left to right
  9. 16 x 20 filter
  10. Back-Draft DAMPER fits 22" x 22" Plenum for this Multifuel Furnace
  11. LEAVES used as Back-Draft DAMPER in old existing Furnace
  12. Flue Exhaust Pipe mounted outside in installation
  13. Sketch Drawing of Example as PRIMARY STANDALONE FURNACE
  14. Sketch Drawing of Example it as a SECOND FURNACE installed in PARALLEL

FUEL PRICES

     Worried about RISING fuel prices?...well don't worry. Just buy a MULT-FUEL stove, furnace, boiler, or fireplace insert and SWITCH to another (cheaper) fuel such as CORN, WOOD PELLETS or big HARD RED WINTER WHEAT ... or switch grass, or any BIO-MASS fuel of-the-future. The latest prices are posted in bags of sizes 40lb, 50lb, or 55lb where a bushel of corn is 55lb bag. BLUE SEAL STOVE CORN is in 40lb bags. Whole corn at a farm feed dealer is usually bagged in 50 bags. Only elevator grain (corn) is bagged in 55lb bushel bags. WOOD PELLETS come in a smaller bag (40 lb), and they burn less-hot than corn or other bio-mass material.

  1. CORN in IOWA................................................. Sept 1, 2014.........$3.76/bu. bag
  2. CORN in EASTERN OHIO ...............................Sept 1, 2014 .......$4.07/bu. bag
  3. CORN in NEBRASKA .......................................Sept 1, 2014 .....$3.72/bu.bag
  4. Blue Seal STOVE CORN in NH.........................Sept 1, 2014 .....$7.79/40lb.bag
  5. Blue Seal STOVE CORN in VERMONT ..........Sept 1, 2014.......$7.92/40lb.bag
  6. Blue Seal STOVE CORN in MAINE ................. Sept 1, 2014......$7.41/40lb.bag
  7. Blue Seal STOVE CORN in MASS ....................Sept 1, 2014.......$7.99/40lb.bag
  8. Blue Seal STOVE CORN in NEW YORK .........Sept 1, 2014.......$7.99/40lb.bag
  9. Blue Seal STOVE CORN in PENN ....................Sept 1, 14..........$7.63/40lb.bag

  10. WOOD PELLETS in IOWA ............................Sept 1, 2014 .......$4.75/40lb.bag
  11. WOOD PELLETS in NEBRASKA ......................Sept 1, 14 .......$4.87/40lb.bag
  12. WOOD PELLETS in OHIO........ ........................Sept 1, 14 .......$5.25/40lb.bag
  13. WOOD PELLETS NEW YORK ........................Sept1, 14 .......$5.49/40lb.bag
  14. WOOD PELLETS in PENN .............................Sept 1, 14 .......$5.98/40lb.bag
  15. WOOD PELLETS in MAINE ......................Sept 1, 2014 .........$5.25/40lb.bag
  16. WOOD PELLETS VERMONT ........................Sept 1, 14 .......$5.65/40lb.bag
  17. WOOD PELLETS NEW HAMPSHIRE............Sept 1, 14 .......$5.75/40lb.bag
  18. WOOD PELLETS IN MASS .....................Sept 1, 2014...........$5.99/40lb.bag

  19. SOYBEANS in IOWA............................... Sept 1, 2014 ..........$9.97/bu. bag
  20. SOYBEANS in NEBRASKA..................... Sept 1, 2014 .........$9.60/bu. bag
  21. BIG RED WHEAT NEBRASKA .....................Sept 1, 2014 .....$5.11/bu. bag
  22. BIG RED WHEAT MONTANA................... Sept 1, 2014 .......$4.94/bu. bag
  23. BIG RED WHEAT CANADA ....................Sept 1, 2014 .........$5.23/bu. bag
  24. CHERRY PITS MICHIGAN.......................Sept 1, 2014..........$7.25/50lb.bag
  25. CHERRY PITS OREGON..........................Sept 1, 2014...........$6.75/50lb.bag
  26. CHERRY PITS CALIFOR.........................Sept 1, 2014...........$7.25/50lb.bag
  27. OLIVE PITS CALIFORNIA.........................Sept 1, 2014..........$6.25/50lb.bag
  28. SUNFLOWER BLACK SEEDS..................Sept 1, 2014........$15.95/50lb.bag

FEATURES

Heat Output of Model III is 110,000 BTU/Hr. with heating speed adjustment from 50,000 to 110,000 BTU heating 2000 to 4,500 Square Feet will enable it to be speed-adjusted to fit the installation space. Model III has a very large Blower Motor (1/2 Amp) with variable speeds up to 1650 CFM. Model I heating output is 80,000 BTU/Hr. and will heat up to 3500 Square Feet. Note a Model IV at 165,000 BTU/Hr will heat up to 6500 Square Feet. Model I has a 210 lb Hopper Bin and Model II has 320 lbs, and Model III has a 250 lb Hopper Bin. They burn Corn, Woods Pellets, Cherry Pits, Olive Pits, Soy Beans, Processed Silage, Bio-Mass, Etc. Room Air on Model I is 1250 CFM, Model II is 1600 CFM, Model III is 1650 CFM (1/2 Amp variable speeds). The Cold-Air Return take-off module can be mounted on either side of the furnace and it has a slot for a 16"x20" Filter. There are Options (see below) available such as (1) Heating Electric Element of 15 to 20 kWatts mounted in front of the Cold-Air Return, (2) Hot-water Coils to heat domestic hot water.

OPTIONS

OPTIONS available are as follows: (1) Model III (Three) at 120,000 BTU/Hr sold in this listing (same price), (2) Model I (One) at 80,000 BTU/Hr subtract $2800, (3) Model IV (Four) at 165,000 BTU/Hr add $2000, (4) Square Duct BACK-DRAFT Damper 22"x22" add $250, (5) Leafs (four) BACK-DRAFT Damper for Existing Furnace, (6) Electric Heating Element 15-20 kW inserted in front of Cold-Air Return add $1000, (7) Hot Water Coil to heat Hot Domestic Water add $650, (8) 12-pak Air Filters 16 X 20 X 1 inches add $49, (9) Flue Exhaust Kit (4" dia) add $465, (10) Basement 6 Foot Flue Extention add $150, (11) Rear-Wall Fresh Air Kit add $145, (12) Wall Digital Thermostat $68, Wall Dial-Indicator Thermostat $35, (13) Remote Control Thermostat $225, (14) Corn Screener/Cleaner $65, (15) Shop Vac $225.

THERMOSTATIC CONTROL

Multifuel Pellet Furnace only:The Thermostat must be installed on an inside wall and located where it is not likely to be affected by the draft coming from an air outlet. It should be set at least 5 Degrees Fahr above your old existing furnace so that the old funace will only serve as a backup and come on only if needed. The themostat will hookup to the multifueled pellet furnace at different locations subject to what type it is either millivolt (dry contact) or 24 VAC. Check your operator's manual for hookup locations.

Combination Multifuel Pellet-Electric: NOTE: If your old existing furnace fuel is more expensive than electric heat, then you may want to use the Electrical Element Option as a backup. Otherwise you may not need the Optional Electric Element as a backup. The Combination model uses two thermostats, one for Multifuel Pellet and a second for Electric Heating Element. Both must be located at the same height from the floor. If the main thermostat (Multifuel Pellet) calls for heat and that demand is not satisfied with the energy supplied by the Multifuel Pellet, then the optional Electrical Heating unit (Electrical Element) will take over and will maintain the home's temperature at the setting programmed on the second thermostat (e.g. the Electric Element option thermostat). Each thermostat hooks up to the furnace central processing unit at a different location, check the Operator's Manual.

POWER OUTAGE BACKUP MODULE

A Power-Outage Module (1000 watts) is available at $179 to supply 115 VAC to your crucial electrical devices ... a smart item to have as backup in power outages. Use this module for POWER OUTAGES and you can run it from any 12 VOLT BATTERY either a Car battery or a Deep Cycle Battery. It supplies 1000 WATTS of 115 VAC POWER with two outlets and battery cables are supplied. It will will run a variety of devices such as a CORN STOVES, WOOD PELLET STOVES , furnaces, computers, appliances, lights, sump pumps. It even has a USB Type A outlet that allows charging of IPOD's, Blackberrys, and Cell Phones. SIZE: 10 inches Wide, 5 inches High, 15 inches Long, WEIGHT: 15 lbs. Larger 1575 Watt POWER priced at $250, still Larger 2500 Watt POWER priced at $350.

WARRANTY

There is a LIMITED LIFETIME WARRANTY on the heat exchanger, combustion chamber, auger, door, etc., and 5 YEAR WARRANTY on stainless steel fire box, heat shields, and ash drawer, 2 Years Warranty on electronics. Labor Warranty cover 1 to 3 years, and the availablity of labor coverage on a warranty is very unusual as most manufacturers don't have it. NOTE that Re-sale by individuals or un-authorized dealers will result in the warranty being invalidated. Be careful from whom you buy. We are a Dealer specializing in corn stoves and can help you through your installation as well as and trouble shooting if necessary. Be careful as others do not have the capability to do that.

DUCTWORK INSTALLATION SUGGESTIONS

You will need Duct Back-Draft Dampers. You will need a back-draft damper installed in BOTH this multi-fuel Furnace and your Old furnace. For your Multi-fuel Furnace we sell a 22" x 22' Back-Damper Frame (see picture) that contains 4 leafs that are gravity-drop. We also sell another set of 4 leafs for your Old Existing Furnace that you can mount just above the furnace in the ductwork. Another option is to have a contractor make one for you. Unless the customer is a technical handyman, he (she) may want to hire a licensed certified HVAC mechanical contractor to install it. You can also hire a sheet metal fabricator to do it. Note: unless you insert back draft dampers for each furnace your system will not work correctly. When one furnace is off, the damper gravity flaps close and prevent back draft from the other existing furnace (when it is running). You can make your own rectangular back-draft damper for both your new and existing furnace out of square aluminum sheet metal flaps that are hinged and drop down with gravity. Do not use gavanized metal for damper blades as it weighs too much. You place this right above the top opening of your existing furnace and when the furnace turns on, the air blows up through the flaps. When the existing furnace shuts off, the gravity flaps fall back down and cover the opening to prevent back draft (from the other furnace). A contractor could also do this for you...it is simple and economical. If you are having difficulty making or finding a back-draft damper, then call us.

OPERATING AND INSTALLATION INSTRUCTIONS

Winning bidders will be immediately mailed our 54 page OWNER'S MANUAL so they may read it and prepare for the future delivery of their Corn furnace (stove). In the Owner's Manual is a step by step instruction for installation of this Multi-fuel Furnace as a Primary Furnace located side by side to your Old Furnace. We recommend you run our Multi-fuel as a primary to achieve your desired temperature and use your old furnace as a backup and dial-down the thermostat to your old furnace about 5 Degrees lower than what you are confortable with. Your Old furnace should only fire-up in an emergence back-up role. Do NOT run off the same thermostat as for one to be a backup for the other, then the thermostats have to be set differently.

Do NOT get rid of your Old Furnace but keep it as an emergency back-up. Use our Mult-fuel Unit as your primary furnace set to produce heat at 5 Degrees higher than your Old Furnace. Do not use one thermostat for both furnaces. The Multi-fuel Pellet unit must have it's own thermostat. Those planning on running the Multifuel Pellet Unit as a standalone, are advised to run it one full year in parallel to there old existing furnace so they can become familiar with the multi-fuel furnace and reduce risks. Customers keeping their old furnace need NOT buy the backup Optional Electric Heating Element if the cost of electric is greater than the cost of the fuel for their old furnace.

Flue Exhaust Vent Kit (not provided) must be purchased and it is available from us. Exhaust Flue Vent Kit can be purchased separately from us at your request and/or check our Ebay Store. Up-The-Basement-Wall Extension of 6 feet with another 90 turn is available. You will need a Fresh Air Intake Kit that can be purchased from us and it be used to avoid room air vacuum and draw oxygen-rich air in from the outside. Inside air is saturated with human-breathed carbon dioxide and your furnace likes oxygen-rich air from the outside. Your multi-fuel furnace will run better with fresh air from the outside.

Crushed Oyster Shell sprinkled in the hopper bin facilitates a cleaner burning of corn and helps avoid any Clinker formation. You can also use pelletized lime instead of crushed oyster shell. The unit is NEW in a box/crated pallet.

SHIPPING

Customer may pick this item up in person or have it shipped by a commercial freight carrier 650 lbs to the nearest large-city Main Terminal serving the customer's geographic area. The Customer will drive a pickup truck down to this Main Terminal and the Freight Company will load the unit into their truck with a fork-lift truck. For another $50.00 we can ship direct to a local business with a loading dock and fork-lift truck. Lumber Yards, Farm Quipment Dealers, and local Manufacturers are good candidates for local businesses. Shipping costs to the USA mainland will be from $245.00 to $345.00 with an average of $295.00; therefore we are charging a flat rate of $295.00. Call for a quote outside of the U.S. such as Canada.

ACTIVE BIDDERS PLEASE PROVIDE ME YOUR PHONE & E-MAIL

Active bidders please provide me with your telephone number(s) and E-mail. This may increase your chance of getting the item in which you are bidding. Good communication exchange and successful bidding go hand-in-hand. Just a request and a suggestion.

SPECIFICATIONS

MODELS I, II, and III are available. Heat Output Model III is 120,000 BTU/hr w 240 lbs Hopper Bin, Model II is 105,000 BTU/Hr w 320 lb Hopper Bin, Model I is 80,000 BTU/Hr w 210 lb Hopper Bin. Heat Output is 50,000 to 120,000 BTU/Hr. (At a special request a Model IV at 165,000 BTU/Hr is available.) Heating Capacity ranging from 2,000 to 4,500 Square Feet, Room Blower G-10 speed 1650 CFM with 1/2 hp motor (max 0.20" WC), Hot Air Plenum 22" X 22" and Cold Air Return Plenum 16-1/8" x 21-5/16", with size-matching Back-Draft Dampers (Option). Flue Exhaust Pipe 4" diameter. Fresh air 3" diameter. Hopper Bin Capacities 210, 240 lbs, Return-Air Filter Slot 16x20x1 inches, Weights of furnaces: Model I is 450 lbs, Model II is 500 lbs, Model III is 600 lbs weight of shipping with crate/pallet is over 650 lbs, Dimensions: Model I: 25-1/2 inches Wide, 47 inches High, 35-1/2 inches Deep; Model II is 29 inches Wide x 43 inches Deep x 44 inches High; Model III: Width 26-1/4 inches, Height 47 inches, Depth 56-1/4 inches. Auto-Ignition, Thermostatic Control Option, 85% Efficient. Electrical 120 VAC, 6 Amps, 60 Hz, a POWER OUTAGE Module is available, Safety Tested and Listed to CAN/CSA B366.1, UL 391, CAN/CSA C22.2 no 236, UL 1995, ASTM E1509, ULC/ORD-C1482. It meets EPA test standard emissions. Manufacturer: American Heating Systems

QUESTIONS

For questions, comments, or to Buy-It-Now through Ebay, contact: Corn Stoves of Iowa, Dealer, 1312 1st Avenue, N.W., Cedar Rapids, IA 52405, 319-298-0500Color=red>, FAX 319-298-0500 (call us to turn FAX on), E-mail: Use the Ebay Ask-a-questionColor=blue> system which is highlighted in blueColor=blue> located at the bottom of the listing in the far lower left-hand side.... Also check out my Ebay Store at:


On Nov-07-05 at 07:51:15 PST, seller added the following information: Always buy from a DEALER. Never buy from individuals.
Feature 7
0.0
Feature 8
0.0
Feature 9
0.0
Feature 10
self
Related Items
Jumbo Wood Pellet Stove Furnace,55,000 BTU, 350lb Hoppr
Jumbo Wood Pellet Stove Furnace,55,000 BTU, 350lb Hoppr
Your Price: $2,350.00
FORCED-AIR ONE CORN WOOD PELLET MULTIFUEL FURNACE STOVE
FORCED-AIR ONE CORN WOOD PELLET MULTIFUEL FURNACE STOVE
Your Price: $3,385.00
Forced-Air II (Two) Corn Wood Pellet Multifuel Furnace Stove
Forced-Air II (Two) Corn Wood Pellet Multifuel Furnace Stove
Your Price: $3,495.00
Combo I Corn Multifuel Furnace Boiler Stove 70,000 BTU
Combo I Corn Multifuel Furnace Boiler Stove 70,000 BTU
Your Price: $2,885.00
  
Browse Similar Items